Flat Roof Repair in Sandwich IL 60548

Locally Owned & Operated

HOME PROS ROOFING

Looking for the right Roofing company for your home or property? Since 1980 we have been providing Roofing services to the Sandwich area.

(844) 359-2189

(Sandwich IL 60548) �” 

If you’re looking for flat roof repair information, you’ve come to the right place. The procedure varies with the type of roofing system, but here are the steps for the most common type where I live.

It is called “modified bitumen” (pronounced buy-TOO-men) and consists of a tough mat embedded in a special asphalt formula that includes elastic additives. That allows Rubber Roof Repair Sandwich IL 60548 the material to expand and contract with temperature changes. The surface is covered with ceramic granules to provide solar protection.

Modified bitumen or “modified” as it is usually called, is especially popular on small residential jobs. That’s because it doesn’t require a hot asphalt kettle along with the inherent safety hazards and obnoxious fumes.

Modified can be installed several different ways, but Sandwich IL 60548 one of the most common methods is with a propane torch. That is also the technique responsible for most of the leak problems with this system when the seams are not heated properly. If you overheat the material, too much asphalt flows away from the seam. Not enough heat results in cold seams that are not completely bonded. Either case Roofing Felt Sandwich IL 60548 creates seams that are vulnerable to water intrusion. If the roof ponds water and the roofer didn’t install a protective mid-ply, leaks are nearly inevitable.

Fortunately, this is a fairly simple flat roof repair. You will need these materials:

Flashing cement. Be sure to get the MB (modified bitumen) variety, as the standard type is not 100% compatible.

Membrane. Either 4″ or 6″ Sandwich IL 60548 is fine, but be sure to get fiberglass rather than cotton, as it lasts a lot longer.

Granules. For a small repair, you might find enough loose ones on the roof or in the gutter to reuse.

Start by CAREFULLY probing the seams with a small pen knife, looking for voids. Ideally, the seams should have about ½” of asphalt bleed-out. Any Sandwich IL 60548 areas that don’t are suspect.

The seams need to be both clean and dry to get a good flat roof repair. Spread a thin layer of flashing cement directly over the problem area, slightly wider than your membrane. Test the bond you are making by “tapping” the cement with your trowel. If it comes up, leaving bare patches of modified, the Sandwich IL 60548 surface is still too wet or too dirty.

Next, keeping the membrane taunt, set it in the thin bed of flashing cement. Work it in with your trowel until the membrane is embedded tightly.

Then spread another layer of flashing cement over the membrane. Again, you don’t need a lot. Just enough to cover the scrim is sufficient.

To complete your flat roof Sandwich IL 60548 repair, broadcast granules into the fresh cement. That will dress up the repair and protect it from the sun.

Video: How to install a Classicbond EPDM flat Roof

Video: Flat Roof Leaks

Video: Rubber roofing - drip edge installation on flat roof

Video: How to repair a flat roof leak Underwater permanently - Karnak 19 Ultra Rubberized Flashing

Video: How repairs are made of EPDM and Torch Down Rubber Roofs

Video: Rubber Roof Repair Southborough MA

Business Results 1 - 10 of 5

Affordable Roofing
18 Reviews
Contractors, Roofing, Home Inspectors
Phone:
1500 Dearborn Ave, Affordable Roofing Inc, Aurora, IL 60505

ABC Roofing & Siding
10 Reviews
Roofing
Phone:
688 N Heartland Dr, Sugar Grove, IL 60554

Berg Roofing & Home Improvements
11 Reviews
Roofing, Windows Installation, Gutter Services
Phone:
900 Ogden Ave, Ste 155, Downers Grove, IL 60515

Valley Chimney Sweep & Restoration
38 Reviews
Chimney Sweeps, Fireplace Services
Phone:
8940 B Route 34, Yorkville, IL 60560

Prusak Construction & Roofing
6 Reviews
Roofing, Gutter Services, Insulation Installation
Phone:
8907 Odell Ave, Bridgeview, IL 60455

Business Results 1 - 10 of 8

Extreme Exteriors Inc.



Robinson Roofing & Sheet Metal, Inc.



Advanced Roofing Inc.



A & B Exteriors LLC



Honey-Do Home Improvements



DSCo. Roofing & Siding



A.R Roofing Siding & Gutters Inc.



SW Roofing



GET A QUOTE NOW

For quality workmanship and service for your residential and commercial Roofing needs, choose a company with over 38 years of service in the Sandwich area.

Highly Rated

Integrity, quality workmanship and attention to detail have made us one of the most reliable Roofing companies in Sandwich.

Quality Service

We focus on making the process as least disruptive as possible to our clients

Affordable Prices

We work hard to keep our costs low and transfer these efficiency savings on to our customers

100% Illinois Licensed Experts

We can complete any size project  in a timely manner, without skipping any steps  or cutting any corners.

GET A QUOTE NOW

(844) 359-2189